Vol. 4 No. 2 (2026): July-December
1-12
2026-10-30
Open Access

Optimizing Pipe Diameters in Drip Irrigation Systems through Spatial Grouping of Subplots into Irrigation Shifts

А.Арифжанов
Л.Самиев
С.Жалилов
А.Турсун
Х.Жалилова
М.Реимбаев
https://doi.org/10.35938/jhee-2026-1-00006

Received: 2026-10-23

Published: 2026-10-30

pdf
Crossmark Crossmark

Abstract

Efficient hydraulic design of drip irrigation systems requires pipe sizing to account for the spatial distribution of irrigation demand and the sequence of system operation. When pump capacity limits the area irrigated simultaneously, different combinations of active subplots can produce different hydraulic conditions despite maintaining the same total discharge. This study develops a method that integrates spatial subplot grouping into operating shifts with hydraulic network analysis to support pipe diameter selection. The method combines equal-area field subdivision, max–min pairing based on centroid distances, pump discharge constraints, and hydraulic calculations for each operating shift. An irregular field of approximately 19.02 ha was divided into 12 subplots and organized into six paired shifts. Each planned shift covered approximately 3.17 ha at a discharge of 111.24 m³ h⁻¹, with a scheduled irrigation sequence lasting 18.81 h. Centroid distances between paired subplots ranged from 287.20 to 349.24 m. Preliminary hydraulic calculations covering 11 connected subplots showed that the five complete paired shifts required pumping heads of 22.71–25.00 m at approximately equal inlet discharge. The maximum mainline velocity was 0.98 m s⁻¹, below the adopted limit of 2.2 m s⁻¹. These results demonstrate that equal discharge does not eliminate differences in hydraulic loading and that pipe sizing must consider the governing operating shift. The proposed approach can support preliminary design and operational assessment of drip irrigation networks on irregular fields where pump capacity requires rotational irrigation, providing a basis for comparing subplot groupings and evaluating commercial pipe diameters.

Keywords

List of references

  1. Pourmahmoud, J.; Hashemy Shahdany, S.M.; Roozbahani, A. Practical Drought Risk Assessment and Management Framework: A Step toward Sustainable Modernization in Agricultural Water Management. J. Hydrol. (Amst). 2024, 644, doi:10.1016/j.jhydrol.2024.132121.

  2. Elmahdi, A. Addressing Water Scarcity in Agricultural Irrigation: By Exploring Alternative Water Resources for Sustainable Irrigated Agriculture. Irrigation and Drainage 2024, 73, 1675–1683.

  3. Hou, P.; Ma, C.; Wang, J.; Li, Y.; Zhang, K.; Hou, S.; Li, J.; Sun, Z.; Xiao, Y.; Li, Y. Failure Behavior of Pressure Compensating Emitter under Different Operation Pressures in Drip Irrigation Systems. Agric. Water Manag. 2024, 297, doi:10.1016/j.agwat.2024.108835.

  4. Xing, S.; Du, K.; Liu, N.; Li, M.; Li, W.; Zhang, J.; Yin, F.; Zhang, J.; Wang, Z. Effect of Dynamic Pressure and Emitter Type on Irrigation and Fertigation Uniformity of Drip Irrigation Systems. Agric. Water Manag. 2025, 312, doi:10.1016/j.agwat.2025.109418.

  5. Wang, Y.; Zhang, Y.; Wang, W.; Liu, Z.; Yu, X.; Li, H.; Wang, W.; Hu, X. A Review of Optimal Design for Large-Scale Micro-Irrigation Pipe Network Systems. Agronomy 2023, 13.

  6. Fan, K.; Zhao, T.; Yu, X.; Wang, W.; Hu, X.; Ran, D.; Huo, X.; Wang, Y.; Pi, Y. Synchronization Optimization of Pipeline Layout and Pipe Diameter Selection in a Drip Irrigation Network System Based on the Jaya Algorithm. Water (Switzerland) 2024, 16, doi:10.3390/w16202913.

  7. Peretti, F.; Menapace, A.; Zanfei, A.; Righetti, M. Optimal Irrigation Scheduling for Sustainable Agriculture: Minimising Energy Costs in Rotational Management. Agric. Water Manag. 2025, 322, doi:10.1016/j.agwat.2025.109986.

  8. Zhang, X.; Li, Y.; Wang, L.; Mao, B.; Yu, E.; Mu, Q.; Shan, M. Field-Calibrated Hydraulic Feedback for Optimizing Rotational Irrigation Grouping in Cotton Drip-Irrigation Networks. Sci. Rep. 2026, doi:10.1038/s41598-026-67861-8.

  9. Lyu, H.; Guo, X.; Ai, Y.; Yang, A. Cooperative Optimization Design and Layout of Water Supply Facilities for Agricultural Sprinkler Irrigation Systems. Applied Sciences (Switzerland) 2026, 16, doi:10.3390/app16062741.

  10. Yang, F.; Li, H.; Jiang, Y. A Review of Pressure Regulation Technologies for Irrigation Pipeline Systems. Agriculture (Switzerland) 2025, 15.

  11. González-Pavón, C.; Palau, C.V.; Juárez, J.M.; Guillem-Picó, S.; Balbastre-Peralta, I. Optimization of Multioutlet Hydrant Location and Pressurized Irrigation Network Layout Using the GRASP Metaheuristic. Journal of Agricultural Engineering 2025, 56, doi:10.4081/jae.2025.1633.

  12. Li, M.; Bai, D.; Li, L. Optimization Design of Drip Irrigation System Pipe Network Based on PSO-GA: A Case Study of Northwest China. Processes 2025, 13, doi:10.3390/pr13051485.

  13. Carravetta, A.; Del Giudice, G.; Fecarotta, O.; Morani, M.C.; Ramos, H.M. A New Low-Cost Technology Based on Pump as Turbines for Energy Recovery in Peripheral Water Networks Branches. Water (Switzerland) 2022, 14, doi:10.3390/w14101526.

  14. Paudel, P.P.; Adhikari, S. Technical Feasibility and Economic Analysis of Solar Photovoltaic Water Pumping System for Sustainable Irrigation in Nepal: A Case Study. International Journal of Sustainable Engineering 2025, 18, doi:10.1080/19397038.2025.2590115.

  15. Pedras, C.M.G.; Pereira, L.S.; Gonçalves, J.M. MIRRIG: A Decision Support System for Design and Evaluation of Microirrigation Systems. Agric. Water Manag. 2009, 96, 691–701, doi:10.1016/j.agwat.2008.10.006.

  16. Carrión, F.; Tarjuelo, J.M.; Hernández, D.; Moreno, M.A. Design of Microirrigation Subunit of Minimum Cost with Proper Operation. Irrig. Sci. 2013, 31, 1199–1211, doi:10.1007/s00271-013-0399-8.

  17. Moreno, M.A.; del Castillo, A.; Montero, J.; Tarjuelo, J.M.; Ballesteros, R. Optimisation of the Design of Pressurised Irrigation Systems for Irregular Shaped Plots. Biosyst. Eng. 2016, 151, 361–

  18. 373, doi:10.1016/j.biosystemseng.2016.10.005.

  19. Baiamonte, G. Explicit Relationships for Optimal Designing Rectangular Microirrigation Units on Uniform Slopes: The IRRILAB Software Application. Comput. Electron. Agric. 2018, 153, 151–168, doi:10.1016/j.compag.2018.08.005.

  20. Palau, C.V.; Arviza, J.; Balbastre, I.; Manzano, J. DIMSUB, a Computer Program for Designing Microirrigation Subunits. Tool Definition and Case Studies. Sci. Agric. 2020, 77, doi:10.1590/1678-992x-2018-0184.

  21. Patel, N.; Rajput, T.B.S.; Kumar Dinkar, D.; Ram, S.; Singla, S.K. DOMIS: A Decision Support System for Design and Cost Estimation of Micro-Irrigation Systems; 2018; Vol. 115;.

  22. Sharu, E.H.; Ab Razak, M.S. Hydraulic Performance and Modelling of Pressurized Drip Irrigation System. Water (Switzerland) 2020, 12, doi:10.3390/w12082295.

  23. Barberena, I.; Campo-Bescós, M.A.; Casalí, J. Precision Agriculture ’25 168. QDrip: A QGIS-Based Tool for the Spatial Layout and Cost Minimization of Drip Irrigation Subunits;

  24. Shaheemath Suhara, K.K.; Ravikumar, V.; Kannan, B.; Duraisamy, M.R.; Ganapati, P.S. Development of a Web-Based Simulation Application for Efficient Drip Irrigation Submain Design. Journal of Applied and Natural Science 2023, 15, 1195–1203, doi:10.31018/jans.v15i3.4799.

  25. Córdoba, A.T.; Manzano, J.M. Reducing Flow Heterogeneity in Drip Irrigation Networks Using Genetic Algorithms. Irrigation and Drainage 2025, 74, 957–969, doi:10.1002/ird.3050.

  26. Li, Y.; Saiyue, C. Coordinated Optimization of Pipe Network Layout and Pipe Diameters in a Multi-Source Irrigation System. Industrial Engineering Journal 2024, 27, doi:10.3969/j.issn.1007-7375.220255.

  27. Samarinas, N.; Gravani, A.; Evangelides, C.; Loukas, A. A Smart Pipe Length Splitting Method for Cost Minimization of a Pressurized Irrigation Network. A Case Study in Greece 2024.

  28. Khalil, E.M.; El-Fitiany, F.A.; Abourohiem, M.A.; Abdelrazek, A.M. Economic Assessment of Using Booster Pumps and Hydrant Sectoring in Pressurized Irrigation Networks (Case Study: Kostol Area, Egypt). KSCE Journal of Civil Engineering 2024, 28, 495–501, doi:10.1007/s12205-023-0705-9.

  29. Creaco, E.; Barbero, G.; Montanaro, A.; Reduzzi, M. Effective Optimization of Irrigation Networks with Pressure-Driven Outflows at Randomly Selected Installation Nodes. Sci. Rep. 2023, 13, doi:10.1038/s41598-023-45844-3.

  30. A. Arifjanov, T. Kaletova, D. Abduraimova, L. Samiev, and X. Jalilova, “Evaluation of the hydraulic efficiency of the sprinkler irrigation system,” in IOP Conference Series: Earth and Environmental Science, 2022, p. 12131.

  31. A. Arifjanov, L. Samiev, D. Abduraimova, and K. Jalilova, “Sustainable green development: Water-saving irrigation technologies,” in E3S Web of Conferences, 2024, p. 5002.

  32. A. Aybek, S. Luqmon, A. Dilbar, and J. Khumora, “SELECTING AN EFFECTIVE SPRINKLER IRRIGATION SYSTEM SPACING: BASED ON ISODENSITY CONTOUR MAPPING- VORONOI-LIKE CONNECTION- HOTSPOT CLUSTERING MODELS,” Water Conserv. Manag., vol. 9, no. 3, pp. 01–09, Jun. 2025, doi: 10.26480/wcm.03.2025.446.454.

  33. A. Arifjanov, L. Samiev, K. Jalilova, S. Jalilov, U. Vokhidova, and E. Tursunova, “Analysis and design of the trajectory of water droplets from sprinklers using optical observation and mathematical modeling,” J. Sustain. Dev. Energy, Water Environ. Syst., vol. 14, no. 1, pp. 1–25, Mar. 2026, doi: 10.13044/j.sdewes.d13.0647.

  34. Samiev, L., Abduraimova, D., Jalilova, K., Gong, P., Jalilov, S., Liu, H., Makhmudov, B., & Gafforova, M. (2026). Adapting China’s innovative water-saving technologies to Uzbekistan: Needs, opportunities, and approaches. Water Conservation and Management (WCM), 10(3), 667–677.

About the Authors

А.Арифжанов
obi-life@mail.ru
Л.Самиев
luqmonsamiev@gmail.com
С.Жалилов
jalilovsirojiddin1997@gmail.com
Tashkent Institute of Irrigation and Agricultural Mechanization Engineers, National Research University, State Key Laboratory of Ecological Safety and Sustainable Development in Arid Lands, Xinjiang Institute of Ecology and Geography, Chinese Academy of Science
А.Турсун
arken@ms.xjb.ac.cn
State Key Laboratory of Ecological Safety and Sustainable Development in Arid Lands, Xinjiang Institute of Ecology and Geography, Chinese Academy of Science
Х.Жалилова
xumora798911@gmail.com
М.Реимбаев
reimbayevmard1202@gmail.com

License

Copyright (c) 2026 Journal of Hydraulic and Environmental Engineering

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

How to Cite

Optimizing Pipe Diameters in Drip Irrigation Systems through Spatial Grouping of Subplots into Irrigation Shifts. (2026). Journal of Hydraulic and Environmental Engineering, 4(2), 1-12. https://doi.org/10.35938/jhee-2026-1-00006

Most read articles by the same author(s)

Similar Articles

You may also start an advanced similarity search for this article.


ISSN 2181-3949 (Online)